Workers were on scene to clean up the oil spill in Abbotsford at Trans Mountain Pipeline’s Sumas pump station in June 2020. (File photo by Shane MacKichan)

Workers were on scene to clean up the oil spill in Abbotsford at Trans Mountain Pipeline’s Sumas pump station in June 2020. (File photo by Shane MacKichan)

TSB releases final report on June 2020 oil spill in Abbotsford

Transportation Safety Board says pipeline fitting to blame for spill of up to 190K litres

A one-inch pipeline fitting has been identified as the source of a crude-oil spill last June at Trans Mountain Pipeline’s Sumas pump station in Abbotsford.

The Transportation Safety Board (TSB) of Canada on Tuesday (April 13) released the findings of its final report into the matter.

The report states that the spill – amounting to 150,000 to 190,000 litres – resulted when a one-inch compression fitting separated from tubing on a section of above-ground piping adjacent to the building that houses the “equation of state” (EOS) system.

“The failed compression fitting was used to join tubing from the discharged mainline to the EOS system,” the report states.

“From the point of release, the oil had followed a path into the pump station’s surface drainage system, through an oil-water separator, and into a culvert that discharges surface water into the south section of the property.”

As a result, 7,000 litres of the oil migrated to the agricultural field in the south section, the TSB said.

RELATED: B.C. Indigenous leaders speak out after 150,000 litres of oil spill in Abbotsford

RELATED: Inclusion of Indigenous reps after a spill part of ‘reconciliation’: Suzuki Foundation

The agency said that during the site cleanup, approximately 143,000 litres of the product was recovered, including about 6,600 litres from the south section.

The TSB said the compression fitting was installed in 2015, using the manufacturer’s instructions.

The fitting was tested in December 2015 and was found to have no leaks, the report indicates.

On the day of the spill – June 12, 2020 – alarms were triggered to indicate that a spill had occurred, and an automatic-shutdown process began, the report states.

However, the valves required to isolate the section of tubing in question were manual and were not part of this process. They remained open until Trans Mountain personnel were able to safely enter the site about five hours after the alarm sounded, the report indicates.

Meanwhile, the oil releasing from the EOS system reached the oil-water separator and continued to accumulate until it could not longer be trapped effectively, the TSB said.

The separator does not have an automated isolation system or manual valves.

“Therefore, once oil began flowing into the agricultural field, there was no means to stop it until operators could isolate the source of the release on the EOS system.”

The report states that once the source of the leak was established, Trans Mountain placed vacuum trucks at the oil-water separator and along the fence line separating the north and south sections of the property.

Site remediation started the following day, and included excavating the affected soils and recovering the free product from the groundwater, the report adds.

The TSB said a “multi-year remediation plan” was developed for contaminants that could not be removed from the site.

“The most appropriate remediation methods will be selected and implemented based on the results of continued monitoring and testing of the soil and groundwater.”

The TSB said the Canada Energy Regulator conducted emergency management of the site, did field inspections, and has monitored the progress of remediation activities.

The report says the actions taken by Trans Mountain have included developing a procedure to verify the integrity of the existing tubing systems and adding an automated isolation valve on the inlet of the EOS tubing system and a check valve on the inlet.

The company has also agreed to complete upgrades to the Sumas pump station by this summer, including containment and drainage features, a new oil-water separator, and a line containment area around the above-ground piping.

The report says Trans Mountain will also develop an internal standard for the construction and quality assurance of new tubing systems, as well as a procedure for their installation.

The Trans Mountain Pipeline transports petroleum crude oil and refined petroleum products from Edmonton to refineries and terminals in B.C. and Washington state.

Previous spills at the Abbotsford site took place in 2005, involving 210,000 litres, and in 2012, involving 90,000 litres.

RELATED: Delayed response impacted oil spill, says report



vhopes@abbynews.com

Like us on Facebook and follow us on Twitter

EnvironmentTrans Mountain pipeline

Get local stories you won't find anywhere else right to your inbox.
Sign up here

 

The Transportation Safety Board has concluded that a June 2020 oil spill at the Sumas pump station in Abbotsford was the result of a one-inch compression fitting separating from tubing on a section of above-ground piping. (Photo: Transportation Safety Board)

The Transportation Safety Board has concluded that a June 2020 oil spill at the Sumas pump station in Abbotsford was the result of a one-inch compression fitting separating from tubing on a section of above-ground piping. (Photo: Transportation Safety Board)

Just Posted

Ripy Jubbal of Abbotsford has received a 30-month jail sentence for the fraudulent use of credit cards and credit card data. (Facebook photo)
Abbotsford woman sentenced for $80K in fraudulent credit card purchases

Ripy Jubbal and spouse used identities of 19 different victims, court hears

A woman in the Harrison Mills area was attacked by a cougar on Tuesday, May 4. (File photo)
UPDATE: 2 cougars killed following attack in Harrison Mills

Attack victim remains in hospital in stable condition

....
Abbotsford graphic designer pitches Flyers rebrand for AHL team

Alex Svarez suggests new affiliate team turns back the clock and brings back Flyers moniker

Mike Haire, a former vice-principal at W. A. Fraser Middle School in Abbotsford, began court proceedings on Monday, May 3 in New Westminster for two child pornography offences.
Trial paused for former Abbotsford vice-principal charged with child porn

Judge reserves decision on admissibility of evidence against Mike Haire

Abbotsford’s Jake Virtanen is now under investigation from the Vancouver Police Department following sexual misconduct allegations. (John Morrow/Abbotsford News)
Vancouver police investigating sexual misconduct claims against Canucks’ Jake Virtanen

Abbotsford native remains on leave with the Vancouver Canucks following recent allegations

Jose Marchand prepares Pfizer COVID-19 vaccination doses at a mobile clinic for members of First Nations and their partners, in Montreal, Friday, April 30, 2021. The National Advisory Committee on Immunization is coming under fire after contradicting the advice Canadians have been receiving for weeks to take the first vaccine against COVID-19 that they’re offered. THE CANADIAN PRESS/Ryan Remiorz
Trudeau says he is glad he got AstraZeneca, vaccines are only way out of pandemic

‘The most important thing is to get vaccinated with the first vaccine offered to you’

Solar panels on a parking garage at the University of B.C. will be used to separate water into oxygen and hydrogen, the latter captured to supply a vehicle filling station. (UBC video)
UBC parkade project to use solar energy for hydrogen vehicles

Demonstration project gets $5.6M in low-carbon fuel credits

FILE – A student arrives at school as teachers dressed in red participate in a solidarity march to raise awareness about cases of COVID-19 at Ecole Woodward Hill Elementary School, in Surrey, B.C., on Tuesday, February 23, 2021. THE CANADIAN PRESS/Darryl Dyck
B.C. ‘should be able to’ offer 1st dose of COVID vaccine to kids 12+ by end of June: Henry

Health Canada authorized the vaccine for younger teens this morning

A woman wears a face mask and shield to curb the spread of COVID-19 while walking in North Vancouver, B.C., on Wednesday, January 6, 2021. THE CANADIAN PRESS/Darryl Dyck
B.C. CDC updates info, acknowledging small respiratory droplets can spread COVID-19

Large droplets, not aerosols had been fixture of public health messaging for many months

A picture of Shirley Ann Soosay was rendered from a postmortem photographer and circulated on social media. (DDP graphic)
B.C. genealogist key to naming murder victim in decades-old California cold case

In July 1980, Shirley Ann Soosay was raped and stabbed to death

Mary Kitagawa was born on Salt Spring Island and was seven years old when she was interned along with 22,000 B.C. residents in 1942. (B.C. government video)
B.C. funds health services for survivors of Japanese internment

Seniors describe legacy of World War II displacement

Meghan Gilley, a 35-year-old emergency room doctor and new mom was vaccinated from COVID-19 in January, while she was pregnant. She’s encouraging others to do the same. (Submitted)
‘The best decision’: B.C. mom encourages other pregnant women to get COVID-19 shot

Meghan Gilley, 35, delivered a healthy baby after being vaccinated against the virus while pregnant

Former Vernon Panthers football standout Ben Hladik of the UBC Thunderbirds (top, in a game against the Manitoba Bisons, <ins>making one of his 38 Canada West solo tackles in 2019</ins>), was chosen in Tuesday’s 2021 Canadian Football League draft. (Rich Lam - UBC Thunderbirds photo)
B.C. Lions call on Vernon standout in CFL draft

Canadian Football League club selects former VSS Panthers star Ben Hladik in third round of league draft

Most Read